Application characteristics of desulfurization and purification system of biogas desulfurizer
沼氣脫硫器工藝吸收效果好，吸收劑使用率高，可根據鍋爐煤種改變，恰當調理pH值.液氣比等因子，以保證規劃脫硫率的實現；鈉堿循環使用，損耗少，運轉成本低；鈉堿吸收劑反響活性高.吸收速度快，可采用低液氣比，然后既可降低運轉費用；脫硫渣無毒，溶解度極小，無二次污染，可綜合使用。如氣體純度要求更高可運用雙塔。沼氣從厭氧發酵設備產出時，特別是在中溫或高溫發酵時，帶著有大量的H2S 。水與沼氣中的H2S 一起效果，加速了金屬管道.閥門和流量計的腐蝕和阻塞。所以有必要對沼氣進行脫硫處理，以保護下流設備的正常運轉。
Biogas desulfurizer process absorption effect is good, the use of absorbent is high, according to the change of boiler coal, the appropriate adjustment of pH value, liquid-gas ratio and other factors to ensure the realization of the planned desulfurization rate; sodium-alkali recycling, less loss, low operating costs; sodium-alkali absorbent reactivity is high, absorption speed is fast, low liquid-gas ratio can be used, and then The operation cost can be reduced, the desulfurized slag is non-toxic, the solubility is very small, and there is no two pollution, so it can be used in a comprehensive way. If the gas purity requirement is higher, the Twin Towers can be used. Biogas produced from anaerobic fermentation equipment, especially at medium or high temperatures, carries a large amount of H2S. The effect of water and H2S in biogas accelerates the corrosion and blockage of metal pipes, valves and flowmeters. Therefore, it is necessary to desulphurate biogas to protect the normal operation of the down flow equipment.
沼氣脫硫器運用特色：
The characteristics of biogas desulfurizer are:
1.操作安穩，要有適宜的操作彈性
1. stable operation and proper operation flexibility.
2.氣流通過期壓降要小
2. pressure drop during air passage.
3.沼氣脫硫-沼氣脫硫器結構簡略，制作及維修方便，造價低價，運用壽命長
3. biogas desulfurization - biogas desulfurizer has simple structure, convenient production and maintenance, low cost and long service life.
4.不結垢.不阻塞，耐磨損.耐腐蝕
4. no scaling. No blockage, wear resistance. Corrosion resistance.
5.氧化鐵脫硫劑具有強度高.遇沼氣脫硫器-沼氣配套干式脫硫塔的廠家是專門出產銷售糞便處理設備。
5. Ferric oxide desulfurizer has high strength. The manufacturer of dry desulfurization tower with biogas desulfurizer and biogas matching is specialized in producing and selling fecal treatment equipment.



沼氣脫硫器效果：
Effect of biogas desulfurizer
1.可用本地資源替代進口動力，削減國家對進口動力的依靠性；
1., local resources can be used instead of import power to reduce the country's dependence on import power.
2.使我國燃料使用多樣化，削減對一種動力的依靠；
2., diversifying the use of fuel in China and reducing the reliance on a power.
3.一種相對清潔的動力，用沼氣替代礦藏燃料是削減CO2排放的抱負方法（沼氣中主要成分是甲烷，它的溫室效應是二氧化碳的21倍）；
3. A relatively clean power, using biogas instead of mineral fuels is an ambitious way to reduce CO2 emissions (methane is the main component of biogas, and its greenhouse effect is 21 times that of carbon dioxide);
沼氣脫硫器檢修保護狀況：
Maintenance and protection status of biogas desulfurizer
1.定時查看法蘭密封處是否有露氣現象，如有，請緊固螺栓或替換橡膠墊.
1. check regularly whether there is air leakage in the flange seal. If yes, tighten bolts or replace rubber pads.
2.但要定時檢測脫硫前沼氣中H2S的含量，還要檢測脫硫后的H2S含量，當脫硫功率低于90%時，闡明脫硫劑已接近飽滿硫容，脫硫劑已失效，應替換脫硫劑，可從脫硫塔底部放掉部分失效的脫硫劑，再從頂部彌補部分新的脫硫劑。
2. However, the content of H2S in biogas before desulfurization should be detected regularly, and the content of H2S after desulfurization should also be detected. When the desulfurization power is below 90%, it is clarified that the desulfurizer is close to the full sulfur capacity and the desulfurizer is invalid. The desulfurizer should be replaced. Some of the invalid desulfurizer can be removed from the bottom of the desulfurization tower and some of the new desulfurizer can be made up from the top.
山東恒能環保能源設備有限公司,對沼氣脫硫感興趣的朋友可以關注我們http://www.twld888.cn，更多精彩內容知識敬請期待
Shandong Heneng Environmental Protection Energy Equipment Co., Ltd., interested in biogas desulfurization friends can pay attention to our http://www.twld888.cn, more exciting content knowledge please look forward to